,
(Prepared According to 29 CFR 1910.1200) Date Prepared: January 1998
Date Revised: September, 05
Prepared by: Robert V. Johnson Date Printed: September 11, 2005
|
SECTION 1 - COMPANY &
PRODUCT IDENTIFICATION: |
|||
|
Company
Name: KLEERWITE CHEMICAL Emergency Phone:
800-535-5053 (InfoTrac) |
|||
|
P. O. BOX 10428, BURKE, VA 22009-0428, 703-451-3964; FAX: 703-451-7362 |
|||
|
Trade Name: KLEERWITE BOILER TREATMENT Product Type: BOILER TREATMENT |
|||
|
SECTION 2 - INGREDIENT INFORMATION:
* = HAZARDOUS |
|||
|
CHEMICAL NAME/COMMON NAME |
CAS NO. |
PERCENT |
TLV |
|
* SODIUM HYDROXIDE |
1310-73-2 |
<15% |
2 mg/m3 |
|
SODIUM TRIPOLY PHOSPHATE |
7758-29-4 |
|
|
|
SODIUM SULFITE |
7757-83-7 |
|
|
|
SARA HAZARD TITLE III, SECTION 313-CONTAINS THE STARED
INGREDIENT(S) AT THE INDICATED PERCENTAGES |
|||
|
SECTION 3 - HEALTH HAZARD DATA: |
|||
|
Primary Routes of Exposure Eye[ ] [ X ] Skin [ X ] Oral [ ] Inhalation [ ] Other |
|||
|
Overexposure Effects: Will cause severe eye burns and irritation. Will cause skin burns and irritation.. Ingestion may cause gastrienteritis and mucosal damage. |
|||
|
Threshold Limit Value: Not Established. |
|||
|
H.M.I.S Values: Health (Blue) - 2; Flammability (Red) - 0; Reactivity (Yellow) - 0; Personal Protection - C |
|||
|
Carcinogen or Suspect Carcinogen Ingredients [ ] NTP [ ] IARC [ ] OSHA [ X ] None |
|||
|
SECTION 4 - FIRST AID
MEASURES: |
|||
|
Eyes: Remove contact lenses. Flush eyes with water for 15 minutes, get prompt medical attention. |
|||
|
Skin: Flush skin with water. Remove contaminated clothing. |
|||
|
Ingestion: Give several glasses of water. Do not induce vomiting. If vomiting occurs, replace fluids. NEVER give anything by mouth to an unconscious person. Get medical attention.. |
|||
|
Inhalation: Seek well ventilated area. If irritation persists seek medical attention. |
|||
|
SECTION 5 - FIREFIGHTING MEASURES: |
|||
|
Flash Point (T.C.C.) [X ] None to boiling Flammable Limits Upper: Not Flammable ; Lower: Not Flammable |
|||
|
Extinguishing Media: Foam, CO2, Water fog, BC/ABC Extinguisher may be used in area where material is stored. |
|||
|
Special firefighting Procedures: Use self contained breathing apparatus |
|||
|
Unusual Fire and Explosion Hazards: None known. |
|||
|
SECTION 6 - ACCIDENTAL RELEASE MEASURES: |
|||
|
If Released or Spilled: Stop leaks. Contain spill, absorb with an inert material and place in a suitable container. Flush spill area with large amounts of water. |
|||
|
Waste Disposal Methods: Dispose of wash water and spill byproducts according to State and Federal regulations. |
|||
|
SECTION 7 - STORAGE AND HANDLING INFORMATION: |
|||
|
Store in a cool, dry area. Do not allow product to freeze. Do not get in the eyes, on skin or on clothing. Do not take internally. |
|||
|
SECTION 8 - SPECIAL PROTECTION INFORMATION |
|||
|
Respiratory Protection: Not needed under normal condition of use. |
|||
|
Ventilation Requirements [ X ] Local Exhaust [ ] Mechanical [ ] Other |
|||
|
Protective Gloves: Necessary for any contact. Eye Protection: Safety glasses/ goggles. Other protective Clothing: None needed |
|||
|
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES: |
|||
|
Boiling point (0F.) Above 200°F Density (lb/gl) 8.798 Specific Gravity (H2O = 1) 1.055 pH (1%) = 13.5 |
|||
|
Vapor Pressure (mm Hg) <0.01 mmHg Vapor Density (Air=1) >1.0 |
|||
|
Solubility in water: [X ] Complete [ ] Insoluble [ ] Emulsifiable (or Dispersible) [ ] Slight (or Partial) |
|||
|
Evaporation Rate (vs. Ether) [ ] Faster [X ] Slower [ ] About the same |
|||
|
Appearance and Odor: Brown, odorless liquid. |
|||
|
SECTION 10 - STABILITY AND REACTIVITY: |
|||
|
Stability: Stable Incompatibility: Strong alkalis: oxidizers Hazardous Decomposition Products: Toxic oxides of carbon and sulfur. |
|||
|
SECTION 11 - TRANSPORTATION INFORMATION: |
|||
|
Proper Shipping Name: CORROSIVE LIQUIDS, n.o.s. (CONTAINS SODIUM HYDROXIDE) |
|||
|
D.O.T. Hazard Class: 8 UN Number: UN-1760 Packaging Group: PGII Label Required: CORROSIVE |
|||